Baja Marine Outlaw 40 Bedienungshandbuch

Baja MarineOwner’s Manual40 OutlawOwner’s Manual Part Number: MRP 1817554© Baja Marine Corporation 2006RSpeed changes you.TM.

viii40 Outlaw® Information in this publication is based upon the latest product specications available at printing. Baja® Marine Corporation reserves

40 Outlaw®1.1SeCtiOn 1 • SaFetySAFE boating means:• Knowing the limitations of your boat• Following the "Rules of the Road"• Keeping a sh

40 Outlaw®1.2SeCtiOn 1 • SaFety2. leGallY ManDaTeD MiniMuM requireD equipMenTThe following equipment is the minimum required by the U.S. Coast Guard

40 Outlaw®1.3SeCtiOn 1 • SaFetySymptoms of carbon monoxide poisoning are dizziness, ears ringing, headaches, nausea, and unconsciousness. Get fresh a

40 Outlaw®1.4SeCtiOn 1 • SaFetyEven strong swimmers can tire quickly in the water and drown due to exhaustion, hypothermia, or both. The buoyancy p

40 Outlaw®1.5SeCtiOn 1 • SaFetyDrugs and/or alcohol impair the operator's ability to control the boat safely.Death or serious injury can r

40 Outlaw®1.6SeCtiOn 1 • SaFetyWhen engine is running, keep passengers away from areas not designed for riding, such as seat backs, bow, gunwales, t

40 Outlaw®1.7SeCtiOn 1 • SaFetyDeath or serious injury can result if you fail to observe these safety rules:• Anyone who controls the boat must have

40 Outlaw®1.8SeCtiOn 1 • SaFetyThe wind speed and wave height specied as the upper limit for your category of boat does not mean that you or your pas

40 Outlaw®1.9SeCtiOn 1 • SaFetyShut engine off if an object is struck or if you run aground.Check for hull leaks and propulsion system damage, befor

Baja Marine COrpOratiOn, 2600 Sea ray Blvd., KnOxville, tn 37914FOr inFOrMatiOn Call 1-865-971-6270 Or Fax 1-865-971-6716internet addreSS: http://www

40 Outlaw®1.10SeCtiOn 1 • SaFetySKIING SIGNALS (FIG. 1.10.1)DIVERS FLAGS(FIG. 1.10.2)CODE ALPHAFLAGSPORT DIVER'SFLAGREDWHITEBLUEWHITETurn - Arm r

40 Outlaw®1.11SeCtiOn 1 • SaFetya. MeDical eMerGencYYou may be far from professional medical help when you are boating. At least two people on board

40 Outlaw®1.12SeCtiOn 1 • SaFetye. collisions anD leakinGIn the event of collisions and leaking:• Slow down or stop to reduce water intake, unless m

40 Outlaw®1.13SeCtiOn 1 • SaFety! WARNINGA wide variety of components used on this vessel contain or emit chemicals known to the State

40 Outlaw®1.14SeCtiOn 1 • SaFetyNOTICEIt is illegal for any vessel to dump plastic trash anywhere in the ocean or navigable waters of the United State

40 Outlaw®1.15SeCtiOn 1 • SaFety20. nauTical TerMsAbeam – object 90 degrees ( 90°) to center line on either side of boat.Abaft – a point on a boat th

40 Outlaw®1.16SeCtiOn 1 • SaFety21. keY To sYMbols on conTrols & prinTsThese symbols may be found on your controls and gauges and/or used in this

40 Outlaw®1.17RSpeed changes you.TM.22. WarninG label locaTionswarning laBel lOCatiOnS(Fig 1.17.1)Located in Owner’s PacketCalifornia Residents OnlyT

40 Outlaw®1.18RSpeed changes you.TM.THIS PAGE INTENTIONALLY LEFT BLANK

40 Outlaw®2.1SeCtiOn 2 • general BOat arrangeMent! CAUTIONDo Not use cleats for lifting.2. passenGer locaTions1. When the boat is moving, all passe

i40 Outlaw®welCOMeCongratulations on becoming the new owner of the world’s #1 performance boat. Baja® Marine Corporation welcomes you in

40 Outlaw®2.2SeCtiOn 2 • general BOat arrangeMent3. basic boaT DiMensions anD clearances (uniTeD sTaTes sTanDarD s.a.e.)40 Outlaw specificaTionsOvera

40 Outlaw®2.3SeCtiOn 2 • general BOat arrangeMentbasic boaT DiMensions anD clearances (MeTric)40 Outlaw SpeCiFiCatiOnSOverall Length...

40 Outlaw®2.4SeCtiOn 2 • general BOat arrangeMent6. General Deck laYouTGENERAL DECK LAYOUT(FIG. 2.4.1)FWDREAR(AFT)LEFT(PORT)RIGHT(STBD)CleatCleatDeck

40 Outlaw®2.5SeCtiOn 2 • general BOat arrangeMent7. DescripTion of Major conTrolsa. Gear shifT anD ThroTTle conTrolThe shift/throttle control unit f

40 Outlaw®2.6SeCtiOn 2 • general BOat arrangeMentc. Trailer sWiTchThe trailer switch (Power Tilt) is not to be confused with the Power Trim function.

40 Outlaw®2.7SeCtiOn 2 • general BOat arrangeMent8. iMporTanT GauGesa. TachoMeTer anD hour MeTerThe tachometer (see Figure 2.7.2) indicates th

40 Outlaw®2.8SeCtiOn 2 • general BOat arrangeMentinSerting the aFt reMOvaBle navigatiOn/anChOr light (lOCated at the Stern OF the BOat) (Fig 2.8.1)ANC

3.140 Outlaw®SeCtiOn 3 • uSing yOur BOat1. pre-launch, launch anD posT-launch checklisTListed below are the critical items you must check and do each

3.2SeCtiOn 3 • uSing yOur BOat40 Outlaw®3. fuelinG The boaTThe fuel ll cap is located on the port side of the boat (Figure 3.2.1). Do not mistake th

3.340 Outlaw®SeCtiOn 3 • uSing yOur BOat• Shut off gas burning appliances (gas stove, etc.).• Close all hatches, doors, and keep engine

ii40 Outlaw® THIS PAGE INTENTIONALLY LEFT BLANK

3.4SeCtiOn 3 • uSing yOur BOat40 Outlaw®• If there are passengers not wearing PFDs, the PFDs must be readily accessible. “Readily accessible” m

3.540 Outlaw®SeCtiOn 3 • uSing yOur BOatit is recommended that the bilge blower run all the time the engine is running.6. Place drive unit in full DO

3.6SeCtiOn 3 • uSing yOur BOat40 Outlaw®10. sTeerinG sYsTeMsYour Baja® may be will be equipped with one of two types of steering. Please re

3.740 Outlaw®SeCtiOn 3 • uSing yOur BOatb. poWer sTeerinGThe power steering system is an enclosed push-pull cable that is hydraulically assisted (pow

3.8SeCtiOn 3 • uSing yOur BOat40 Outlaw®THIS PAGE INTENTIONALLY LEFT BLANK

4.140 Outlaw®SeCtiOn 4 • Bilge & underwater gear1. bilGea. fuel & oil spillaGeRegulations prohibit discharging fuel or oily waste in navigab

4.240 Outlaw®SeCtiOn 4 • Bilge & underwater gearExcept for checking the operation of the bilge pump using the ON position, leave the switch in the

4.340 Outlaw®SeCtiOn 4 • Bilge & underwater gearc. iMpacT To sTern DriveThe stern drive can be damaged by impact, either while trailering or boat

4.440 Outlaw®SeCtiOn 4 • Bilge & underwater gearf. Install the thrust washer, propeller, continuity washer, thrust hub, propeller nut retain

40 Outlaw®5.1SeCtiOn 5 • Fuel SySteM1. fuel sYsTeMSection 3 • Using Your Boat contains important fueling information. Take time to read all the

iii40 Outlaw®intrOduCtiOn1. This ManualThe material within this manual and your Owner’s Manual Packet:• Gives you basic safety information• Describ

40 Outlaw®5.2SeCtiOn 5 • Fuel SySteM2. fuelinG precauTionsCertain precautions must be carefully and completely observed every time a boat is fu

40 Outlaw®5.3SeCtiOn 5 • Fuel SySteM• Electrical equipment, including blowers – power off.• Doors, hatches – closed.• Smoking material – extinguish

40 Outlaw®5.4SeCtiOn 5 • Fuel SySteMTHIS PAGE INTENTIONALLY LEFT BLANK

40 Outlaw®6.1RSpeed changes you.TM.SeCtiOn 6 • eleCtriCal SySteMS1. elecTrical sYsTeMs DirecT currenT (Dc)The 12 volt direct current (DC) elect

40 Outlaw®6.2SeCtiOn 6 • eleCtriCal SySteMSRSpeed changes you.TM.Protective terminal covers, such as rubber boots on electrical connections, must b

40 Outlaw®6.3SeCtiOn 6 • eleCtriCal SySteMSRSpeed changes you.TM.Zinc anodes require replacement about every six months, if the boat is operated

40 Outlaw®6.4SeCtiOn 6 • eleCtriCal SySteMSRSpeed changes you.TM.ignitiOn SwitCh (Fig. 6.4.1)Note: This drawing contains information proprietar

6.540 Outlaw®RSpeed changes you.TM.drive puMp with K-plane triM taBS (Fig 6.5.1)DIODEDIODEBLUE/WHITEGREEN/WHITERED100AMP100AMP14 AWG YELLOW14 AWG WHIT

6.640 Outlaw®RSpeed changes you.TM.SwitCh panel wire inFOrMatiOn – triple (Fig 6.6.1)HEAT SEALED 14-16 NO. RING TERMINALDDAAA(.156) SPLASH PROOF CONNE

6.740 Outlaw®RSpeed changes you.TM.SwitCh panel wire inFOrMatiOn – twin (Fig 6.7.1)HEAT SEALED 14-16 NO. RING TERMINALDDAAA(.156) SPLASH PROOF CONNECT

iv40 Outlaw® 6. hull iDenTificaTion nuMber (hin)The “Hull Identication Number” located on the starboard side of the transom, is the most impor

6.840 Outlaw®RSpeed changes you.TM.wiring harneSS inFOrMatiOn (Fig 6.8.1)12GA.ORANGE(DOCK.LT.)12GA.BLACK(DOCK.LT.)14GA.BLACK(CABIN)14GA.GRAY(179"

6.940 Outlaw®RSpeed changes you.TM.dC diStriButiOn wiring inFOrMatiOn (Fig 6.9.1)STEREOAMP16 BRN/GRN16 DARK BLUE16 PUR/GRN16 TAN/BLU-GRN16 YEL/RED-GRN

6.1040 Outlaw®RSpeed changes you.TM.2312312312914 LT.BLUE14 PURPLE14 LT.GREENGRN TAPERED TAPE8 WAY MOLDED FEMALE (STBD)16 TAN/BLU12131314 REDTRIMSTBD2

6.1140 Outlaw®RSpeed changes you.TM.gauge panel wiring inFOrMatiOn (Fig 6.11.1)HEAT SEALED 14-16 NO. RING TERMINALD(.156) SPLASH PROOF CONNECTOR PLUGB

6.1240 Outlaw®RSpeed changes you.TM.LABEL WITH THE LETTER "E"12"PLUG 7Pin 0460-204-0490 Deutsch DTH Series PlugReceptacle DTH04-1-4-P#1

40 Outlaw®7.1SeCtiOn 7 • OptiOnS & aCCeSSOrieS1. opTions & accessories locaTionsFigure 7.1.1 shows the location of some of the components. T

40 Outlaw®7.2SeCtiOn 7 • OptiOnS & aCCeSSOrieS2. auToMaTic fire exTinGuisher sYsTeM (opTion)The 40 Outlaw may be equipped with an automati

40 Outlaw®7.3SeCtiOn 7 • OptiOnS & aCCeSSOrieSBimini Top or sunshade must not be used when the vessel speed exceeds 45 MPH. Damage to boat or bim

40 Outlaw®7.4SeCtiOn 7 • OptiOnS & aCCeSSOrieSREFER TO OWNER'S MANUAL PACKET FOR INSTRUCTIONS AND WARRANTY INFORMATION ON DEPTH FINDER.8.

40 Outlaw®7.5SeCtiOn 7 • OptiOnS & aCCeSSOrieSc. vacuflush® heaD (opTion)The VacuFlush® head utilizes a HEAD SYSTEM breaker on the main

v40 Outlaw®RSpeed changes you.TM.abouT Your express liMiTeD WarranTYBaja Marine offers an Express Limited Warranty on each new Baja purchased through

40 Outlaw®7.6SeCtiOn 7 • OptiOnS & aCCeSSOrieSTHIS PAGE INTENTIONALLY LEFT BLANK

8.140 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCeITEMREQUIREDMAINTENANCE/SERVICEREFERENCE SOURCE BEFOREEVERY USEAFTER FIRST20 H

8.2 40 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCesuMMarY GuiDe for inspecTion, service anD MainTenance*Use in salt water or ot

8.340 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCe2. useful service inforMaTionOWNERHOME PORTBOAT NAMEREGISTRATION NUMBER

8.4 40 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCe3. inspecTion, service anD MainTenance proTocola. bilGe areaMany of your bo

8.540 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCe• Check your rst aid kit, making certain it is complete and that

8.6 40 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCe5. fiTTinG ouT afTer sToraGea. fuel sYsTeMCheck the entire fuel system for

8.740 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCe• Check fuel lines for damage and/or leaks. Make sure that they do not c

8.8 40 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCe8. quick reference checklisTAs the owner/operator of a Baja® Boat, you are r

8.940 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCequick reference checklisT (conT’D)*If engine fails to start, refer to the Engi

vi40 Outlaw® 40 Outlaw Owner’S Manual • taBle OF COntentSinTroDucTion1. This Manual ...iii2.

8.10 40 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCec. DeparTinGGeneral 1. Passengers/Crew ...

8.1140 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCequick reference checklisT (conT’D) 3. Ignition ...

8.12 40 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCe9. afTer MarkeT equipMenT checklisTAny safety or operational equipment adde

8.1340 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCe10. MainTenance loGFollow the recommended maintenance listed on pages 1 &

8.14 40 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCeMainTenance loG (conT’D) Date Maintenance Description Engine Hours

9.140 Outlaw®SeCtiOn 9 • Care & reFiniShingYour new boat has been designed to provide you with years of enjoyment and satisfaction. In order to m

9.2SeCtiOn 9 • Care & reFiniShing40 Outlaw®• Minor scratches and deeper stains that do not penetrate the gelcoat may be removed by light sanding

9.340 Outlaw®SeCtiOn 9 • Care & reFiniShingThe fabric should be cleaned regularly before substances such as dirt, pollen, etc. are allo

9.4SeCtiOn 9 • Care & reFiniShing40 Outlaw®This Page inTenTionally lefT Blank

index40 ouTlaw®indexAAccessories. See Options & Accessories LocationsBBilge 4.1Blower 4.2Maintenance 4.2, 8.4Pump 4.1Boarding 3.3Breakers.

vii40 Outlaw®2. Engines and Stern Drive...4.2A. Maintenance and Service ... 4.2B. Vibr

index 40 ouTlaw®This Page inTenTionally lefT Blank