Baja Marine Outlaw 35 Bedienungshandbuch

Baja MarineOwner’s Manual20 OutlawOwner’s Manual Part Number: MRP 1811975© Baja Marine Corporation 2006RSpeed changes you.TM.

viii20 Outlaw® Information in this publication is based upon the latest product specications available at printing. Baja® Marine Corporation reserves

20 Outlaw®1.1SeCtiOn 1 • SaFetySAFE boating means:• Knowing the limitations of your boat• Following the "Rules of the Road"• Keeping a sh

20 Outlaw®1.2SeCtiOn 1 • SaFety2. leGallY ManDaTeD MiniMuM requireD equipMenTThe following equipment is the minimum required by the U.S. Coast Guard

20 Outlaw®1.3SeCtiOn 1 • SaFetySymptoms of carbon monoxide poisoning are dizziness, ears ringing, headaches, nausea, and unconsciousness. Get fresh a

20 Outlaw®1.4SeCtiOn 1 • SaFetyEven strong swimmers can tire quickly in the water and drown due to exhaustion, hypothermia, or both. The buoyancy p

20 Outlaw®1.5SeCtiOn 1 • SaFetyDrugs and/or alcohol impair the operator's ability to control the boat safely.Death or serious injury can r

20 Outlaw®1.6SeCtiOn 1 • SaFetyWhen engine is running, keep passengers away from areas not designed for riding, such as seat backs, bow, gunwales, t

20 Outlaw®1.7SeCtiOn 1 • SaFetyDeath or serious injury can result if you fail to observe these safety rules:• Anyone who controls the boat must have

20 Outlaw®1.8SeCtiOn 1 • SaFetyThe wind speed and wave height specied as the upper limit for your category of boat does not mean that you or your pas

20 Outlaw®1.9SeCtiOn 1 • SaFetyShut engine off if an object is struck or if you run aground.Check for hull leaks and propulsion system damage, befor

Baja Marine COrpOratiOn, 2600 Sea ray Blvd., KnOxville, tn 37914FOr inFOrMatiOn Call 1-865-971-6270 Or Fax 1-865-971-6716internet addreSS: http://www

20 Outlaw®1.10SeCtiOn 1 • SaFetySKIING SIGNALS (FIG. 1.10.1)DIVERS FLAGS(FIG. 1.10.2)CODE ALPHAFLAGSPORT DIVER'SFLAGREDWHITEBLUEWHITETurn - Arm r

20 Outlaw®1.11SeCtiOn 1 • SaFetya. MeDical eMerGencYYou may be far from professional medical help when you are boating. At least two people on board

20 Outlaw®1.12SeCtiOn 1 • SaFetye. collisions anD leakinGIn the event of collisions and leaking:• Slow down or stop to reduce water intake, unless m

20 Outlaw®1.13SeCtiOn 1 • SaFety! WARNINGA wide variety of components used on this vessel contain or emit chemicals known to the State

20 Outlaw®1.14SeCtiOn 1 • SaFetyNOTICEIt is illegal for any vessel to dump plastic trash anywhere in the ocean or navigable waters of the United State

20 Outlaw®1.15SeCtiOn 1 • SaFety20. nauTical TerMsAbeam – object 90 degrees ( 90°) to center line on either side of boat.Abaft – a point on a boat th

20 Outlaw®1.16SeCtiOn 1 • SaFety21. keY To sYMbols on conTrols & prinTsThese symbols may be found on your controls and gauges and/or used in this

20 Outlaw®1.17RSpeed changes you.TM.warning laBel lOCatiOnS(Fig 1.18.1)California Residents OnlyThe above warning is attached to the steering wheel pr

20 Outlaw®1.18RSpeed changes you.TM.THIS PAGE INTENTIONALLY LEFT BLANK

20 Outlaw®2.1SeCtiOn 2 • general BOat arrangeMent! CAUTIONDo Not use cleats for lifting.2. passenGer locaTions1. When the boat is moving, all passe

i20 Outlaw®welCOMeCongratulations on becoming the new owner of the world’s #1 performance boat. Baja® Marine Corporation welcomes you in

20 Outlaw®2.2SeCtiOn 2 • general BOat arrangeMent3. basic boaT DiMensions anD clearances (uniTeD sTaTes sTanDarD s.a.e.)20 Outlaw specificaTionsOvera

20 Outlaw®2.3SeCtiOn 2 • general BOat arrangeMentbasic boaT DiMensions anD clearances (MeTric)20 Outlaw SpeCiFiCatiOnSOverall Length...

20 Outlaw®2.4SeCtiOn 2 • general BOat arrangeMent6. General Deck laYouTGENERAL DECK LAYOUT(FIG. 2.4.1)FWDREAR(AFT)LEFT(PORT)RIGHT(STBD)Engine HatchCl

20 Outlaw®2.5SeCtiOn 2 • general BOat arrangeMent7. DescripTion of Major conTrolsa. Gear shifT anD ThroTTle conTrolThe shift/throttle control unit f

20 Outlaw®2.6SeCtiOn 2 • general BOat arrangeMentc. Trailer sWiTchThe trailer switch (Power Tilt) is not to be confused with the Power Trim function.

20 Outlaw®2.7SeCtiOn 2 • general BOat arrangeMent8. iMporTanT GauGesa. TachoMeTer anD hour MeTerThe tachometer (see Figure 2.7.2) indicates th

20 Outlaw®2.8SeCtiOn 2 • general BOat arrangeMentinSerting the aFt reMOvaBle navigatiOn/anChOr light (lOCated at the Stern OF the BOat) (Fig 2.8.1)ANC

3.120 Outlaw®SeCtiOn 3 • uSing yOur BOat1. pre-launch, launch anD posT-launch checklisTListed below are the critical items you must check and do each

3.2SeCtiOn 3 • uSing yOur BOat20 Outlaw®3. fuelinG The boaTThe fuel ll cap is located on the port side of the boat (Figure 3.2.1). Do not mistake th

3.320 Outlaw®SeCtiOn 3 • uSing yOur BOat• Shut off gas burning appliances (gas stove, etc.).• Close all hatches, doors, and keep engine

ii20 Outlaw® THIS PAGE INTENTIONALLY LEFT BLANK

3.4SeCtiOn 3 • uSing yOur BOat20 Outlaw®• If there are passengers not wearing PFDs, the PFDs must be readily accessible. “Readily accessible” m

3.520 Outlaw®SeCtiOn 3 • uSing yOur BOatit is recommended that the bilge blower run all the time the engine is running.6. Place drive unit in full DO

3.6SeCtiOn 3 • uSing yOur BOat20 Outlaw®10. sTeerinG sYsTeMsYour Baja® may be will be equipped with one of two types of steering. Please re

3.720 Outlaw®SeCtiOn 3 • uSing yOur BOatb. poWer sTeerinGThe steering system is an enclosed push-pull cable that is hydraulically assisted (power ste

4.120 Outlaw®SeCtiOn 4 • Bilge & underwater gear1. bilGea. fuel & oil spillaGeRegulations prohibit discharging fuel or oily waste in navigab

4.220 Outlaw®SeCtiOn 4 • Bilge & underwater gearExcept for checking the operation of the bilge pump using the ON position, leave the switch in the

4.320 Outlaw®SeCtiOn 4 • Bilge & underwater gearc. iMpacT To sTern DriveThe stern drive can be damaged by impact, either while trailering or boat

4.420 Outlaw®SeCtiOn 4 • Bilge & underwater gearf. Install the thrust washer, propeller, continuity washer, thrust hub, propeller nut retain

20 Outlaw®5.1SeCtiOn 5 • Fuel SySteM1. fuel sYsTeMSection 3 • Using Your Boat contains important fueling information. Take time to read all the

20 Outlaw®5.2SeCtiOn 5 • Fuel SySteM2. fuelinG precauTionsCertain precautions must be carefully and completely observed every time a boat is fu

iii20 Outlaw®intrOduCtiOn1. This ManualThe material within this manual and your Owner’s Manual Packet:• Gives you basic safety information• Describ

20 Outlaw®5.3SeCtiOn 5 • Fuel SySteM• Electrical equipment, including blowers – power off.• Doors, hatches – closed.• Smoking material – extinguish

20 Outlaw®5.4SeCtiOn 5 • Fuel SySteMTHIS PAGE INTENTIONALLY LEFT BLANK

20 Outlaw®6.1RSpeed changes you.TM.SeCtiOn 6 • eleCtriCal SySteMS1. elecTrical sYsTeMs DirecT currenT (Dc)The 12 volt direct current (DC) elect

20 Outlaw®6.2SeCtiOn 6 • eleCtriCal SySteMSRSpeed changes you.TM.Protective terminal covers, such as rubber boots on electrical connections, must b

20 Outlaw®6.3SeCtiOn 6 • eleCtriCal SySteMSRSpeed changes you.TM.Zinc anodes require replacement about every six months, if the boat is operated

20 Outlaw®6.4SeCtiOn 6 • eleCtriCal SySteMSRSpeed changes you.TM.drive puMp(Fig. 6.4.1)TRAILER TRIMBLUE/WHITEREDGREEN/WHITE14 AWG RED14 AWG GREEN14 AW

20 Outlaw®6.5SeCtiOn 6 • eleCtriCal SySteMSRSpeed changes you.TM.drive puMp w/ K-plane triM taBS (Fig. 6.5.1)TRAILER TRIMBLUE/WHITEREDGREEN/WHITETRAIL

20 Outlaw®6.6SeCtiOn 6 • eleCtriCal SySteMSRSpeed changes you.TM.ignitiOn SwitCh (Fig. 6.6.1)Note: This drawing contains information proprietar

6.720 Outlaw®RSpeed changes you.TM.dC wiring inFOrMatiOn (Fig 6.7.1)

6.820 Outlaw®RSpeed changes you.TM.SwitCh panel wiring inFOrMatiOn (Fig 6.8.1)#1#2#3#4PLUG 18 - Way Deutsch DT Series ReceptacleReceptacle DT0

iv20 Outlaw® 6. hull iDenTificaTion nuMber (hin)The “Hull Identication Number” located on the starboard side at the rear corner, is the

20 Outlaw®7.1SeCtiOn 7 • OptiOnS & aCCeSSOrieS1. opTions & accessories locaTionsFigure 7.1.1 shows the location of some of the components. T

20 Outlaw®7.2SeCtiOn 7 • OptiOnS & aCCeSSOrieS2. auToMaTic fire exTinGuisher sYsTeM (opTion)The 20 Outlaw may be equipped with an automati

20 Outlaw®7.3SeCtiOn 7 • OptiOnS & aCCeSSOrieS4. canvasBimini Top or sunshade must not be used when the vessel speed exceeds 45 MPH. Damage to b

20 Outlaw®7.4SeCtiOn 7 • OptiOnS & aCCeSSOrieS7. DepTh finDer (opTional)The depth nder that may be installed in your boat is a high-perform

8.120 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCeITEMREQUIREDMAINTENANCE/SERVICEREFERENCE SOURCE BEFOREEVERY USEAFTER FIRST20 H

8.2 20 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCesuMMarY GuiDe for inspecTion, service anD MainTenance*Use in salt water or ot

8.320 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCe2. useful service inforMaTionOWNERHOME PORTBOAT NAMEREGISTRATION NUMBER

8.4 20 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCe3. inspecTion, service anD MainTenance proTocola. bilGe areaMany of your bo

8.520 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCe• Check your rst aid kit, making certain it is complete and that

8.6 20 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCe5. fiTTinG ouT afTer sToraGea. fuel sYsTeMCheck the entire fuel system for

v20 Outlaw®RSpeed changes you.TM.abouT Your express liMiTeD WarranTYBaja Marine offers an Express Limited Warranty on each new Baja purchased through

8.720 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCe• Check fuel lines for damage and/or leaks. Make sure that they do not c

8.8 20 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCe8. quick reference checklisTAs the owner/operator of a Baja® Boat, you are r

8.920 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCequick reference checklisT (conT’D)*If engine fails to start, refer to the Engi

8.10 20 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCec. DeparTinGGeneral 1. Passengers/Crew ...

8.1120 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCequick reference checklisT (conT’D) 3. Ignition ...

8.12 20 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCe9. afTer MarkeT equipMenT checklisTAny safety or operational equipment adde

8.1320 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCe10. MainTenance loGFollow the recommended maintenance listed on pages 1 &

8.14 20 Outlaw®SeCtiOn 8 • required inSpeCtiOn, ServiCe, & MaintenanCeMainTenance loG (conT’D) Date Maintenance Description Engine Hours

9.120 Outlaw®SeCtiOn 9 • Care & reFiniShingYour new boat has been designed to provide you with years of enjoyment and satisfaction. In order to m

9.2SeCtiOn 9 • Care & reFiniShing20 Outlaw®• Minor scratches and deeper stains that do not penetrate the gelcoat may be removed by light sanding

vi20 Outlaw® 20 Outlaw Owner’S Manual • taBle OF COntentSinTroDucTion1. This Manual ...iii2.

9.320 Outlaw®SeCtiOn 9 • Care & reFiniShingThe fabric should be cleaned regularly before substances such as dirt, pollen, etc. are allo

9.4SeCtiOn 9 • Care & reFiniShing20 Outlaw®This Page inTenTionally lefT Blank

index20 ouTlaw®indexAAccessories. See Options & Accessories LocationsBBilge 4.1Blower 4.2Maintenance 4.2, 8.4Pump 4.1Boarding 3.3Breakers.

index 20 ouTlaw®This Page inTenTionally lefT Blank

vii20 Outlaw®secTion 5 • fuel sYsTeM1. Fuel System...............5.12. Fueling Precautions .....